解決燃氣鍋爐缺水事故的方法

時間：2017-03-24作者：河南省四通鍋爐有限公司瀏覽：404

解決燃氣鍋爐缺水事故的方法
The ways to solve gas boiler water shortage accident
1 symbol:
1.1 a low water level alarm **s.
1.2 the water gauge instructions, local water level gauge to reduce or can't see the water level.
1.3 water flow abnormal is less than the steam flow (when the water wall tube or economizer tube damage instead)
1.4 severe water shortage, the main steam temperature is high.


1象征：
1.1發出低水位報警信號。
1.2各水位表指示降低，就地水位計降低或看不到水位。
1.3給水流量不正常的小于蒸汽流量（當水冷壁管或省煤器管損壞時相反）
1.4缺水嚴重時，主汽溫升高。
Two reasons:
2.1 water supply automatic failure.
2.2 improper monitoring water level or wrong operation.
2.3 water supply valve failure.
2.4 water level gauge instructions on the high side, wrong operation.
2.5 the feed water pump failure, feed water pressure drop.
2.6 discharge door serious leakage, water wall, economizer tube blasting.
2原因：
2.1給水自動失靈。
2.2監視水位不當或誤操作。
2.3給水閥門故障。
2.4水位計指示偏高，發生誤操作。
2.5給水泵故障，給水壓力下降。
2.6排污門嚴重泄漏，水冷壁、省煤器管爆破。
3 water treatment:
3.1 when a low water level alarm **s, check the water gauge and relevant meter, to make the right judgment.
3.2 such as water supply, automatic failure should manually and increase the water supply and contact thermal processing, such as drainage work
Shall be immediately stopped.
3.3 if the water pressure is low, should improve water supply pressure, at the same time decrease the steam pressure or lower water temperature.
3.4 if the above measures is invalid, should immediately report the long-term value, reduces the boiler load.
Such as the steam drum water level continues to fall to 3.5-300 - mm, delay of 1 second, MFT protection action, according to emergency boiler stop processing.
3.6 after cause water shortages have been eliminated by comprehensive examination think boiler no damage, slow water according to the value of long order to ignition.
3缺水的處理：
3.1當發出低水位報警信號時，應查看水位表和有關表計，做出正確判斷。
3.2如給水自動失靈，應改手動并加大給水并聯系熱工處理，如有排污工
作應立即停止。
3.3若給水壓力低，應提高給水壓力，同時適當降低汽壓或降低給水溫度。
3.4如采取上述措施無效，應立即匯報值長，降低鍋爐負荷。
3.5如汽包水位繼續下降到-300mm，延時1秒，MFT保護動作，按緊急停爐處理。
3.6缺水原因查明消除后，經全面檢查認為鍋爐無損壞時，按值長令緩慢上水重新點火。
信息來源于



河南省四通鍋爐有限公司專注于1噸燃氣鍋爐價格,2噸燃油鍋爐,4噸*鍋爐,6噸生物質鍋爐,0.3噸燃電鍋爐,0.5噸燃煤鍋爐等

• 詞條

  詞條說明

• 四通鍋爐迎接河南省常委統戰部部長陶明倫視察

  Cross the boiler to meet in henan province standing committee united front work department minister TaoMingLun inspection 四通鍋爐迎接河南省常委統戰部部長陶明倫視察 信息來源于：http://

• 孟加拉客戶來公司考察訂購鍋爐

  孟加拉客戶來公司考察訂購鍋爐 Bangladesh customers to order boiler company inspection 信息來源于：http://

• 李縣長到四通鍋爐演習工作

  Lee county magistrate to cross boiler drill work 李縣長到四通鍋爐演習工作 信息來源于：http://

• 走出**的四通鍋爐

  太康縣四通鍋爐集團有限公司是一家本地企業。上世紀70年代，這家公司還只是一個家庭式的小作坊，生產僅針對農村市場。2000年后，該公司憑借完善的質保體系和**的生產工藝，先后**了國家D級、C級、B級、A級鍋爐生產資質，并獲得太康縣一家由河南省質量監督局頒發的焊工考委會資格。 Taikang county stone boiler group co., LTD. Is a local enterp