DP-series preheating continuous feeding equipment

時間：2013-08-09

DP-series preheating continuous feeding equipment is the most advanced, clean, energy saving and environmental protection metallurgy off gas using equipment in nowadays. This is using the off gas from the electric furnace to preheat the raw materials, and avoided the high failure rate, complicated operation, can not charging materials continuously and etc weakness from Shaft furnace preheating and preheating bucket and etc traditional ways. This system has been put into production in more than 20 factories in china and several other countries. And had gain marked affects in electricity saving, energy saving, production increasing, pollution reduction, and brings great economic benefits for customers.

DP- series preheating continuous feeding equipment has characteristics of continuous feeding, continuous melting, continuous smelting and etc… which’s advantages are: smelting period is short, low power consumption, low noises, low investment cost and etc…
Compare with the traditional EAF, the technical index of continuously preheating and feeding EAF process are:

Production capacity increases more than 10%.
Smelting cycle is shortened by 10-15 Min.
Save energy of 100-120kw.h/t for per ton Steel.
Electrode consumption decreases by 0.5-0.8%, Refractory material consumption reduces by 5%.
20-30% reduction of CO2 volume which is released from per ton of Steel; Production site dustiness less than 10mg/M3.
Dioxin and CO emissions meets relative emission standards, smoke and dust is decreased from 17kg/t to 11kg/t.
Fully utilization of waste heat: On the Conveyor section can preheat the materials up to 300 degree Celsius and higher, and add burner in conveyor section, can raise the materials up to 600 degree Celsius. The rear part of the waste heat can be used to generate electricity or heating by steam which is produced by waste heat boiler, the gas from the boiler basically can go into the bag type dust collector directly. But the traditional electric furnace system off gas must go through the water cooled pipes, air forced cooler and etc equipments, it will consumable much energy to cool the temperature down and then can put the gas go into dust collector, so waste the energy from the off gas.
De-duster Fan power reduces 30%.
Noise is fewer than 90 decibels during the electric furnace smelting cycle.
With fully considering for customers kinds of actual using status, DP- series preheating continuous feeding equipment brings direct economic benefits to customers by lowest failure rate, highest energy saving index, biggest investment return.

DP furnace continuous feeding equipment and technology promotion
Tel: 15090480399; 18937332186
E-Mail: taihangquanli@
website：

Main Technical Specifications

Model Specification of Preheating Channel Dimensions of Raw Materials Processing Rate Electric furnace Capacity
(width*length) (width*depth*length) (t/h) (t)
DP20 1260*65000 300*300*500 120 15-20
DP40 1400*46300 400*400*700 150 30-40
DP60 1840*48800 450*450*1000 200 50-60
DP70 2060*60000 500*500*1100 250 70
DP90 2140*60000 500*500*1100 300 80-90
DP150 2260*65000 500*500*1200 350 100-150

詞條
詞條說明
開始發貨了!舞鋼公司1號爐DP90電爐廢鋼預熱連續加料設備
2018年10月6日，舞鋼公司1號爐DP90電爐廢鋼預熱連續加料設備改造部件開始發貨了! 該項目經過河鋼集團網上招標采購對比，較終仍然采用國內較早研發國產電弧爐連續加料設備廠家河南太行全利重工股份有限公司的改進后*四代較新技術裝備。 1、項目名稱：舞鋼公司1號DP90廢鋼預連續加設改造 2、項目審批機：鋼集團舞鋼公司 3、項目業主名稱：舞陽鋼鐵有限責任公司 4、資金來：企業籌 5、招人名稱：河鋼集
印尼錢王力寶集團**李文正訪問太行全利重工
2012年10月14日，印尼力寶集團董事局**李文正先生一行蒞臨河南太行全利重工股份有限公司工作訪問，隨后與集團公司**和國內相關技術*進行了詳細座談和合作項目的技術咨詢，并對訪問結果表示滿意。印尼力寶集團是在上世紀80年代后期，由“印尼錢王”李文正與印尼首富林紹良攜手創立。力寶集團是印尼較大的金融控股財團，旗下控有各國上市企業20多家，投資領域包括商業銀行、保險、房地產、百貨超市、制造業、
全利重工-中國較大電弧爐廢鋼預熱連續加料研發中心
太行全利重工DP連續加料式電爐是近幾年新投產電爐中比較多的一種爐型，截止2018年3月全利重工已經在國內提供了90多套電爐廢鋼連續加料裝備，產量亞洲**，是全國較大的電爐連續加料電弧爐研發生產基地! 與此同時，河南太行全利重工()在不斷是技術探索和實踐總結中，研制開發出具有****，世界**L型電弧爐廢鋼連續加料設備，并且已經在多家鋼鐵企業成功應用，經濟效益十分顯著!
全利重工:依靠科技獲6億元伊朗鋼鐵工程總承包訂單
? 當前在**經濟下行和國內政策調控的雙重影響下，**鋼材市場需求萎縮，宏觀經濟增速放緩導致下游需求持續不振，預計短期內難有明顯改善。國內外需求均嚴重不足，市場壓力進一步加大，鋼鐵企業競爭加劇、鋼鐵企業為了生存競相控制或減少生產成本，國內與鋼鐵有關聯冶金制造機械企業也是云霧飄渺前途未卜！。然而就在2012年8月3日，河南省鶴壁機械制造業的*企業、全國**的電爐節能煉鋼成套科技裝備生產